网站版权 © 《油气储运》编辑部 陕ICP备11014090号-10
地址：河北省廊坊市金光道51号（065000）；电话：0316-2176193 / 0316-2072055； 传真:0316-2177392； 网址：yqcy.paperonce.org
技术支持：西安三才科技实业有限公司 029-89381847；029-88222991
[1]李印,陈雪见,姜俊浩.大型地下水封洞库运营期涌水量计算与注浆设计[J].油气储运,2022,41(07):847-851858.[doi:10.6047/j.issn.1000-8241.2022.07.013]
LI Yin,CHEN Xuejian,JIANG Junhao.Calculation on water inflow of large underground water-sealed storage during operation and grouting design[J].Oil & Gas Storage and Transportation,2022,41(07):847-851858.[doi:10.6047/j.issn.1000-8241.2022.07.013]
点击复制
LI Yin,CHEN Xuejian,JIANG Junhao.Calculation on water inflow of large underground water-sealed storage during operation and grouting design[J].Oil & Gas Storage and Transportation,2022,41(07):847-851858.[doi:10.6047/j.issn.1000-8241.2022.07.013]
大型地下水封洞库运营期涌水量计算与注浆设计
《油气储运》[ISSN:1000-8241/CN:13-1093/TE]
卷:
41
期数:
2022年07期
页码:
847-851858
栏目:
工艺与工程
出版日期:
2022-07-25
- Title:
- Calculation on water inflow of large underground water-sealed storage during operation and grouting design
- 文章编号:
- 1000-8241(2022)07-0847-05
- Keywords:
- underground water-sealed storage; water inflow; permeability coefficient; numerical simulation; water sealing by grouting
- 分类号:
- TE82
- 文献标志码:
- A
- 摘要:
- 洞室涌水量预测长期以来始终是困扰洞库建设与运营的一大难题，且施工过程中涌水量预测未能与注浆封堵有效结合，容易造成施工期间注浆费用超标、洞库验收困难等问题，严重影响地下洞库的设计、施工及运营。以某地下水封洞库为例，根据地质条件和地下工程布置情况，首先利用FEFLOW软件建立渗流场模型，模拟计算得到未经过注浆封堵条件下的洞库运营期涌水量，并与经验公式计算结果相互验证，确定涌水量推荐值为10115m3/d。结合相关规范要求反算渗透系数，整个库区的平均渗透系数需从1.1×10-5cm/s降至1.09×10-6cm/s，从而有针对性地指导注浆设计。该研究首次将涌水量计算与渗流控制相关联，可准确估算预注浆工程量，指导施工组织设计，有效解决了同类工程普遍存在的涌水量超标而难以验收投产的难题。（图4，参22）
- Abstract:
- Prediction of water inflow in caverns has been a big problem for a long time, and the predication during construction has not been effectively combined with the water sealing by grouting, resulting in excessive grouting cost and difficulty in acceptance of storages during construction, which have caused great problems to the design, construction and operation of underground storages. Herein, a seepage field model was firstly established by FEFLOW software based on the actual geological conditions and the layout of underground works of a underground water-sealed storage, the water inflow of the storage during its operation without water-sealing by grouting was calculated by simulation, and the recommended water inflow value was finally determined to be 10 115 m3/d through the mutual verification with the calculation results of the empirical formula. Further, the permeability coefficient was calculated according to the requirements of relevant specifications. Definitely, the average permeability coefficient of the whole storage area needed to be reduced from 1.1×10-5 cm/s to 1.09×10-6 cm/s, which could guide the grouting design in a targeted way. The calculation of water inflow and seepage control were correlated in the research for the first time, capable of accurately estimating the quantity of pre-grouting and guiding the construction organization design, thus effectively overcoming the common difficulty in acceptance and commissioning of similar projects due to excessive water inflow. (4 Figures, 22 References)
参考文献/References:
[1] 谢楠，林伯强，苏彤，庞连芳.中国石油储备的补仓与释放策略及最优规模分析[J].厦门大学学报（哲学社会科学版），2019（6）：122-137. XIE N, LIN B Q, SU T, PANG L F. Analysis of the replenish and release strategy and optimal scale of China’s petroleum reserves[J]. Journal of Xiamen University (Arts & Social Sciences), 2019(6): 122-137.
[2] 丁国生，丁一宸，李洋，唐立根，武志德，完颜祺琪，等，王云.碳中和战略下的中国地下储气库发展前景[J].油气储运，2022， 41（1）：1-9. DING G S, DING Y C, LI Y, TANG L G, WU Z D, WANYAN Q Q, et al. Prospects of underground gas storage in China under the strategy of carbon neutrality[J]. Oil & Gas Storage and Transportation,2022,41(1): 1-9.
[3] 李锴，郭洁琼，周韬. 中国地下储气库市场化产品研究与经济分析[J].油气储运，2021，40（5）：492-499. LI K, GUO J Q, ZHOU T. Research on market products and economic analysis of underground gas storage in China[J]. Oil &Gas Storage and Transportation, 2021，40（5）: 492-499.
[4] MORFELDT C O. Storage of petroleum products in man-made caverns in Sweden[J]. Bulletin of the International Association of Engineering Geology, 1983, 28(1): 17-30.
[5] 张金龙，冯树荣，胡育林，许卫.我国地下水封石油洞库研究现状及发展动向[J].水力发电，2013，39（11）：80-84. ZHANG J L, FENG S R, HU Y L, XU W. Review and trends on underground oil storage in China[J]. Water Power, 2013, 39(11):80-84.
[6] 管泽英.地下水封石油洞库水幕系统施工技术[J].国防交通工程与技术，2018，16（2）：49-52. GUAN Z Y. Construction techniques for the water curtain system in sealing cave depots of petroleum with underground water[J]. Traffic Engineering and Technology for National Defense, 2018, 16(2): 49-52.
[7] 张磊，胡谋鹏.地下水封洞库竖井与洞室交叉处的稳定性[J].油气储运，2020，39（6）：656-661. ZHANG L，HU M P. Stability at the intersection of shaft and cavern of underground water sealed storage[J]. Oil & Gas Storage and Transportation，2020，39（6）：656-661.
[8] 王者超，李术才，乔丽苹，毕丽平，张振杰.地下石油洞库水封性评价方法体系及应用[J].岩土工程学报，2016，38（11）：2033-2042. WANG Z C, LI S C, QIAO L P, BI L P, ZHANG Z J. Assessment methods for containment properties of underground crude oil storage caverns and their applications[J]. Chinese Journal of Geotechnical Engineering, 2016, 38(11): 2033-2042.
[9] STURK R, STILLE H. Design and excavation of rock caverns for fuel storage—a case study from Zimbabwe[J]. Tunnelling and Underground Space Technology, 1995, 10(2): 193-201.
[10] LEE C, SONG J. Rock engineering in underground energy storage in Korea[J]. Tunnelling and Underground Space Technology, 2003, 18(5): 467-483.
[11] TEZUKA M, SEOKA T. Latest technology of underground rock cavern excavation in Japan[J]. Tunnelling and Underground Space Technology, 2003, 18(2/3): 127-144.
[12] BENARDOS A G, KALIAMPAKOS D C. Hydrocarbon storage in unlined rock caverns in Greek limestone [J]. Tunnelling and Underground Space Technology, 2005, 20(2):175-182.
[13] 李云鹏，彭振华，李俊彦，张彬，石磊.某地下水封洞库涌水量模拟计算[J].勘察科学技术，2018（3）：43-46. LI Y P, PENG Z H, LI J Y, ZHANG B, SHI L. Simulation calculation of water inflow of a groundwater sealed cavern[J]. Site Investigation Science and Technology, 2018(3): 43-46.
[14] 路文龙，周志芳，黄勇.单条裂隙破碎带对地下水封洞库涌水量的影响[J].人民黄河，2014，36（2）：112-114. LU W L, ZHOU Z F, HUANG Y. Effect of single fractured zone on water inflow of underground unlined cavern[J]. Yellow River, 2014, 36(2): 112-114.
[15] 左崇，张继勋，任旭华，方明泉.围岩灌浆深度对水封石油洞库水封效果的影响[J].三峡大学学报（自然科学版），2020，42（1）：30-35. ZUO C, ZHANG J X, REN X H, FANG M Q. Effect of rock grouting depth on containment property of containment oil storage cavern[J]. Journal of China Three Gorges University (Natural Sciences), 2020, 42(1): 30-35.
[16] 梁斌，陈刚，胡成.某地下水封石油洞库渗流场模拟研究及水封效果评价[J].世界核地质科学，2018，35（3）：180-186. LIANG B, CHEN G, HU C. Vadose field simulation and water-sealing effect evaluation of underground petroleum storage caver[J]. World Nuclear Geoscience, 2018, 35(3): 180-186.
[17] 贾甲.基于连续介质理论的地下水封石油洞库渗流场及水封适宜性研究[J].水利与建筑工程学报，2016，14（3）：192-196. JIA J. The seepage field and containment of underground crude-off caverns based on fluid theory of continuous medium[J]. Journal of Water Resources and Architectural Engineering, 2016, 14(3): 192-196.
[18] 巫润建，李国敏，董艳辉，黎明，乔小娟.锦州某地下水封洞库工程渗流场数值分析[J].长江科学院院报，2009，26（10）：87-91. WU R J, LI G M, DONG Y H, LI M, QIAO X J. Analysis of seepage simulation of underground water sealed caverns in Jinzhou[J]. Journal of Yangtze River Scientific Research Institute, 2009, 26(10): 87-91.
[19] 刘贯群，韩曼，宋涛，陈浩.地下水封石油洞库渗流场的数值分析[J].中国海洋大学学报（自然科学版），2007，37（5）：819-824. LIU G Q, HAN M, SONG T, CHEN H. Seepage simulation of underground petroleum storage caverns and necessity analysis of a water curtain system[J]. Periodical of Ocean University of China, 2007, 37(5): 819-824.
[20] 张继勋，杨帆，杨玲，任旭华.改进的水封石油洞库群渗水量预估研究[J].三峡大学学报（自然科学版），2017，39（2）：14-18. ZHANG J X, YANG F, YANG L, REN X H. Improved water seepage prediction in seal petroleum cavern group[J]. Journal of China Three Gorges University (Natural Sciences), 2017, 39(2): 14-18.
[21] 许建聪，郭书太.地下水封油库围岩地下水渗流量计算[J].岩土力学，2010，31（4）：1295-1302. XU J C, GUO S T. Seepage discharge calculation of surrounding rock groundwater in rock caverns sealed oil storage[J]. Rock and Soil Mechanics, 2010, 31(4): 1295-1302.
[22] 郭得福，陈刚，党娜.多相流地下水封液化石油洞库水幕系统的性能评价[J].油气储运，2020，39（9）：1002-1011. GUO D F, CHEN G, DANG N. Performance assessment on water curtain system for multiphase flow water-sealed underground liquefied petroleum storage caverns[J]. Oil & Gas Storage and Transportation, 2020, 39(9): 1002-1011.
相似文献/References:
[1]彭振华,李俊彦,孙承志,等.地下水封洞库的库址选择研究[J].油气储运,2008,27(1):60.[doi:10.6047/j.issn.1000-8241.2008.01.018]
PENG Zhenhua,LI Junyan.Site Determination on Underground Water-sealing Oil Storage in Rock Caverns[J].Oil & Gas Storage and Transportation,2008,27(07):60.[doi:10.6047/j.issn.1000-8241.2008.01.018]
[2]马耀川 潘真.地下水封石油洞库埋深优化方法[J].油气储运,2013,32(5):521.[doi:10.6047/j.issn.1000-8241.2013.05.015]
Ma Yaochuan,Pan Zhen.Method to optimize the buried depth of underground water-sealing oil storage in rock caverns[J].Oil & Gas Storage and Transportation,2013,32(07):521.[doi:10.6047/j.issn.1000-8241.2013.05.015]
[3]朱华,徐佳,刘晓亮,等.地下水封洞库施工期地下水监测系统与应用案例[J].油气储运,2016,35(10):1116.[doi:10.6047/j.issn.1000-8241.2016.10.017]
ZHU Hua,XU Jia,LIU Xiaoliang,et al.Groundwater monitoring system for underground water-sealed storage caverns during the construction and its application cases[J].Oil & Gas Storage and Transportation,2016,35(07):1116.[doi:10.6047/j.issn.1000-8241.2016.10.017]
[4]张磊 胡谋鹏.地下水封洞库竖井与洞室交叉处的稳定性[J].油气储运,2020,39(06):656.[doi:10.6047/j.issn.1000-8241.2020.06.008]
ZHANG Lei,HU Moupeng.Stability at the intersection of shaft and cavern of underground water sealed storage[J].Oil & Gas Storage and Transportation,2020,39(07):656.[doi:10.6047/j.issn.1000-8241.2020.06.008]
[5]郭得福 陈刚 党娜.多相流地下水封液化石油洞库水幕系统的性能评价[J].油气储运,2020,39(09):1002.[doi:10.6047/j.issn.1000-8241.2020.09.006]
GUO Defu,CHEN Gang,DANG Na.Performance assessment on water curtain system for multiphase flow water-sealed underground liquefied petroleum storage caverns[J].Oil & Gas Storage and Transportation,2020,39(07):1002.[doi:10.6047/j.issn.1000-8241.2020.09.006]
[6]荆少东,韩伟民,许国辉,等.基于模糊综合评判与神经网络的岩体质量分级方法[J].油气储运,2022,41(07):832.[doi:10.6047/j.issn.1000-8241.2022.07.011]
JING Shaodong,HAN Weimin,XU Guohui,et al.Rock mass quality classification based on fuzzy comprehensive evaluation and neural network[J].Oil & Gas Storage and Transportation,2022,41(07):832.[doi:10.6047/j.issn.1000-8241.2022.07.011]
[7]王者超,张彬,乔丽苹,等.中国地下水封储存理论与关键技术研究进展[J].油气储运,2022,41(09):995.[doi:10.6047/j.issn.1000-8241.2022.09.001]
WANG Zhechao,ZHANG Bin,QIAO Liping,et al.Research progress on theories and key technologies of underground water-sealed storage in China[J].Oil & Gas Storage and Transportation,2022,41(07):995.[doi:10.6047/j.issn.1000-8241.2022.09.001]
[8]夏喜林,张东焱,夏炳焕,等.地下水封洞库工程技术发展与展望[J].油气储运,2023,42(11):1201.[doi:10.6047/j.issn.1000-8241.2023.11.001]
XIA Xilin,ZHANG Dongyan,XIA Binghuan,et al.Development and outlook of engineering technology for underground water-sealed storage caverns[J].Oil & Gas Storage and Transportation,2023,42(07):1201.[doi:10.6047/j.issn.1000-8241.2023.11.001]
[9]朱志强 卢波 胡伟 叶童.地下水封洞库三维渗控精细模拟及水封性评价[J].油气储运,2025,44(07):1.
Zhu Zhiqiang,Lu Bo,Hu Wei,et al.Three-dimensional seepage control fine simulation and water sealing evaluation of underground water sealed caverns[J].Oil & Gas Storage and Transportation,2025,44(07):1.
[10]庞家伟 丁国平 陈刚 商玮麟. 地下水封洞库水位降深与涌水量的数值分析[J].油气储运,2013,32(9):1007.[doi:10.6047/j.issn.1000-8241.2013.09.019]
Pang Jiawei,Ding Guoping,Chen Gang,et al.Pang Jiawei1,2, Ding Guoping2, Chen Gang2, Shang Weilin2[J].Oil & Gas Storage and Transportation,2013,32(07):1007.[doi:10.6047/j.issn.1000-8241.2013.09.019]
备注/Memo
李印，男，1985年生，高级工程师，2009年硕士毕业于中科院广州地化所地质学专业，现主要从事石油和天然气地下库方面的研究和建设工作。地址：河北省廊坊市广阳区和平路146号， 065000。电话：15933269129。Email：95408504@qq.com
（收稿日期：2020-05-29；修回日期：2022-03-04；编辑：刘朝阳）
更新日期/Last Update:
2022-07-25