PDF下载

[1]张秀杰.减阻剂应用技术研究[J].油气储运,2009,28(10):1-5,18.[doi:10.6047/j.issn.1000-8241.2009.10.001]
　ZHANG Xiujie.Applied Study of Drag Reduction Agent[J].Oil & Gas Storage and Transportation,2009,28(10):1-5,18.[doi:10.6047/j.issn.1000-8241.2009.10.001]

点击复制

减阻剂应用技术研究

《油气储运》[ISSN:1000-8241/CN:13-1093/TE] 卷: 28 期数: 2009年10期页码: 1-5,18 栏目: 出版日期: 1900-01-01

Title:: Applied Study of Drag Reduction Agent

作者:: 张秀杰; 中国石油管道研究中心

Author(s):: ZHANG Xiujie

关键词:: 原油管道; 减阻剂; 增输; 减阻; 技术; 应用

Keywords:: crude oil pipeline; drag reduction agent(DRA); throughput increase; drag reduction; technology; application

DOI:: 10.6047/j.issn.1000-8241.2009.10.001

摘要:: 依据高聚物减阻增输机理,利用加剂前后的管道工作特性曲线,导出了不同流态下的增输率计算公式。由于增输率计算值与实测值对应的加剂流体的雷诺数不同,因此计算值略小于实测值,并得到试验验证。提出了减阻剂的应用范围、应用方法及室内试验和实际应用时应注意的事项。

Abstract:: Based on the mechanism of high polymer in drag reduction and throughput increase,equations to calculate throughput increasing rate at different flow patterns are derived from the characteristic curve of pipeline under the condition of DKA injected or free of DRA.Because calculated values of throughput increasing rate are different from the measured value that is relative to the Reynolds number of DRA-added fluid,the calculated values are lower than the measured value,which is verified by experiments.Technical issues of DRA in application scope,injection method,laboratory experiment and field application are presented.

参考文献/References:

[1] 李国平刘天佑等:高聚物减阻增输机理研究,油气储运,2006,25(7).
[2] 严大凡:输油管道设计与管理,石油工业出版社(北京),1986.
[3] 税碧垣李国平等:EP-W203减阻剂的评价与现场试验,油气储运,2001,20(6).

相似文献/References:

[1]苗青,衣桂影,徐波,等.中国－朝鲜原油管道中方段流动安全性评价[J].油气储运,2011,30(04):252.[doi:10.6047/j.issn.1000-8241.2011.04.003]
　Miao Qing,Yi Guiying,Xu Bo,et al.Flow safety evaluation for China section of China-North Korea Crude Oil Pipeline[J].Oil & Gas Storage and Transportation,2011,30(10):252.[doi:10.6047/j.issn.1000-8241.2011.04.003]
[2]黄启玉,何莎莎.蜡沉积层冲刷实验[J].油气储运,2011,30(04):312.[doi:10.6047/j.issn.1000-8241.2011.04.021]
　Huang Qiyu and He Shasha.Scouring test of wax deposition layer[J].Oil & Gas Storage and Transportation,2011,30(10):312.[doi:10.6047/j.issn.1000-8241.2011.04.021]
[3]张绚,肖刚,齐文远,等.降凝剂在克拉玛依－独山子原油管道的应用[J].油气储运,2011,30(01):49.[doi:10.6047/j.issn.1000-8241.2011.01.013]
　Zhang Xuan,Xiao Gang,Qi Wenyuan,et al.The application of pour point depressant in Karamay-Dushanzi Crude Oil Pipeline[J].Oil & Gas Storage and Transportation,2011,30(10):49.[doi:10.6047/j.issn.1000-8241.2011.01.013]
[4]曹明,曹旦夫,吴杰,等.BEM-JN 油基降粘剂作用机理与应用试验[J].油气储运,2011,30(01):53.[doi:10.6047/j.issn.1000-8241.2011.01.014]
　Cao Ming,Cao Danfu,Wu Jie,et al.Mechanism and performance experiment of oil-based BEM-JN viscosity depressant[J].Oil & Gas Storage and Transportation,2011,30(10):53.[doi:10.6047/j.issn.1000-8241.2011.01.014]
[5]方爱国,薛海鸿.三塘湖原油管道水击保护措施[J].油气储运,2011,30(06):465.[doi:10.6047/j.issn.1000-8241.2011.06.017]
　Fang Aiguo and Xue Haihong.Measures in surge control in Santanghu Oil Pipeline[J].Oil & Gas Storage and Transportation,2011,30(10):465.[doi:10.6047/j.issn.1000-8241.2011.06.017]
[6]鹿钦礼,杜明俊,马贵阳,等.变径管道对冷热原油顺序输送混油的影响[J].油气储运,2011,30(03):183.[doi:10.6047/j.issn.1000-8241.2011.03.007]
　Lu Qinli,Du Mingjun,Ma Guiyang,et al.nfluence of reduced pipeline on the batch transportation of cold-hot contaminated crude oil[J].Oil & Gas Storage and Transportation,2011,30(10):183.[doi:10.6047/j.issn.1000-8241.2011.03.007]
[7]杨法杰,李春漫,张志恒,等.聚 α- 烯烃油品减阻剂悬浮液的稳定性[J].油气储运,2011,30(02):121.[doi:10.6047/j.issn.1000-8241.2011.02.010]
　Yang Fajie,Li Chunman,Zhang Zhiheng,et al.Stability of poly-α-olefin drag reduction agent suspension[J].Oil & Gas Storage and Transportation,2011,30(10):121.[doi:10.6047/j.issn.1000-8241.2011.02.010]
[8]张伟,刘乔,曲岩,等.热油管道总体工艺方案设计与软件开发[J].油气储运,2011,30(05):385.[doi:10.6047/j.issn.1000-8241.2011.05.018]
　Zhang Wei,Liu Qiao,Qu Yan,et al.Design and software development of total technology scheme for hot oil pipeline[J].Oil & Gas Storage and Transportation,2011,30(10):385.[doi:10.6047/j.issn.1000-8241.2011.05.018]
[9]胡森,周广,苗青,等.东部原油管网能耗问题分析[J].油气储运,2010,29(5):395.[doi:10.6047/j.issn.1000-8241.2010.05.026]
　Hu Sen,ZhouGuang,Miao Qing.Energy Consumption Analysis on Eastern Oil Pipeline Network[J].Oil & Gas Storage and Transportation,2010,29(10):395.[doi:10.6047/j.issn.1000-8241.2010.05.026]
[10]徐诚,李玉胜,吴海浩,等.表面活性剂减阻试验研究[J].油气储运,2010,29(2):124.[doi:10.6047/j.issn.1000-8241.2010.02.012]
　Xu Cheng,Li Yusheng,Wu Haihao.Experimental Study on Drag Reduction of Surfactant[J].Oil & Gas Storage and Transportation,2010,29(10):124.[doi:10.6047/j.issn.1000-8241.2010.02.012]
[11]成旭霞,林森,张宁,等.甬沪宁管道添加减阻剂增输试验[J].油气储运,2011,30(10):764.[doi:10.6047/j.issn.1000-8241.2011.10.014]
　Chen Xuxia,Lin Seng,Zhang Ning,et al.Throughput increasing experiment on YongHuNing Oil Pipeline by drag reduction agent injection[J].Oil & Gas Storage and Transportation,2011,30(10):764.[doi:10.6047/j.issn.1000-8241.2011.10.014]
[12]姜和圣,张亮军,段春丽,等.中间管段重复添加减阻剂对管道运行的影响[J].油气储运,2009,28(3):40.[doi:10.6047/j.issn.1000-8241.2009.03.013]
　JIANG Hesheng,ZHANG Liangjun.Influence of DRA Reinjection at Middle Pump Station on the Operation of DRA-added Pipeline[J].Oil & Gas Storage and Transportation,2009,28(10):40.[doi:10.6047/j.issn.1000-8241.2009.03.013]
[13]罗旗荣,曹旦夫,丁友,等.临濮输油管道添加减阻剂运行现场试验[J].油气储运,2005,24(6):31.[doi:10.6047/j.issn.1000-8241.2005.06.009]
　LUO Qirong,CAO Danfu.Site Experiment on the Oil Pipeline Running with DRA for LinPu Oil Pipeline[J].Oil & Gas Storage and Transportation,2005,24(10):31.[doi:10.6047/j.issn.1000-8241.2005.06.009]
[14]税碧垣,关中原,赵丽英,等.苏丹GNPOC原油管道减阻剂工业试验及应用[J].油气储运,2005,24(1):29.[doi:DOI:10.6047/j.issn.1000-8241.2005.01.009]
　SHUI Biyuan,GUAN Zhongyuan.The IndustrialExperiment and Application of EP-W203 DRA in Sudan Oil Pipeline[J].Oil & Gas Storage and Transportation,2005,24(10):29.[doi:DOI:10.6047/j.issn.1000-8241.2005.01.009]
[15]闵希华,孙建刚,汪开雄,等.“两剂”理念引入管道设计的研究与实践[J].油气储运,2004,23(1):39.[doi:10.6047/j.issn.1000-8241.2004.01.012]
　MIN Xihua,SUN jiangang.Research and Practice on the Introduction of Pour Point Depressant and Drag Reduction Agent into the Design of Pipeline[J].Oil & Gas Storage and Transportation,2004,23(10):39.[doi:10.6047/j.issn.1000-8241.2004.01.012]
[16]刘子均,李佩.EP-W203/H型减阻剂在安延管道的试验及应用[J].油气储运,2001,20(11):24.[doi:DOI:10.6047/j.issn.1000-8241.2001.11.007]
　Liu Zijun,Li Pei.The Experiment and Application of EP-W203/H DRA in Ansai-Yan’an Oil Pipeline[J].Oil & Gas Storage and Transportation,2001,20(10):24.[doi:DOI:10.6047/j.issn.1000-8241.2001.11.007]
[17]曹金水.降凝剂与减阻剂联合工业试验[J].油气储运,1997,16(11):34.[doi:10.6047/j.issn.1000-8241.1997.11.011]
　Cao Jinshui.The Joint Site Test of GY Pour Point Depressant and CDR LP Flow Improver[J].Oil & Gas Storage and Transportation,1997,16(10):34.[doi:10.6047/j.issn.1000-8241.1997.11.011]

备注/Memo

收稿日期:2008-12-30。
作者简介:张秀杰,065000,河北省廊坊市金光道51号;电话:(0316)2175877.高级工程师,1961年生,1983年毕业于大庆石油学院应用化学专业,现在中国石油管道研究中心从事减阻剂研究与市场应用的管理工作。

更新日期/Last Update: 1900-01-01